Journey with Confidence RV GPS App RV Trip Planner RV LIFE Campground Reviews RV Maintenance Take a Speed Test Free 7 Day Trial ×
 

Go Back   Montana Owners Club - Keystone Montana 5th Wheel Forum > GENERAL DISCUSSIONS > General Discussions about our Montanas
Click Here to Login

Reply
 
Thread Tools Search this Thread Display Modes
 
Old 11-10-2022, 01:18 PM   #1
GreG L.
Montana Fan
 
Join Date: Jun 2018
Location: Jacksonville
Posts: 354
M.O.C. #21993
Another furnace issue

Hoping this is a common or known issue. Last trip I needed the furnace, it comes on and blows hot air for about 10 or so seconds then shuts off. I can switch it off and back on and it will do the same thing each time.
Any ideas?
 
__________________
I was once intelligent beyond my years. Now, Iím years beyond my intelligence.
2020 Montana 3561 Legacy, everything except paint.
2018 Silverado 3500 DRW, 50Gal Transfer Flow, Andersen hitch.
GreG L. is offline   Reply With Quote
Old 11-10-2022, 01:28 PM   #2
jsb5717
Montana Master
 
jsb5717's Avatar
 
Join Date: Mar 2019
Location: Milwaukie, OR
Posts: 1,197
M.O.C. #23668
Those symptoms could be a few different things. Ours has had those same symptoms a few times…each with a different fix.

The easiest thing to check is the thermal switch. That was our last fix.

Before that I pulled out the manifold and the diffuser was all rusted. Replaced it and it ran great.

Before that the issue was propane volume flow. Replaced the regulator and then it ran great.
__________________

Jeff & Sandi (and Teddy - 7lb Schnorkie)
2018 Montana HC 305RL / HW Progressive EMS / Demco Recon Hitch on B&W Ball
2012 RAM 3500 Big Horn Crew Cab 4x4 SRW / AMP Power Running Boards / Air Bags
jsb5717 is offline   Reply With Quote
Old 11-11-2022, 05:24 AM   #3
RMcNeal
Montana Master
 
RMcNeal's Avatar
 
Join Date: Oct 2019
Location: Jacksonville
Posts: 1,763
M.O.C. #25165
Sometimes spiders or mud dobbers will build a nest in the furnace tube where the propane and air mix causing a low gas flow situation as Jeff mentioned. You can easily check that from the outside and check that the exhaust port is not blocked either.
__________________
Robert & Diana McNeal
2019 Montana Legacy 3791RD 20th Anniversary Edition
2014 F350 4x4 6.7L SRW
RMcNeal is offline   Reply With Quote
Old 11-11-2022, 07:34 AM   #4
Daryles
Montana Master
 
Daryles's Avatar
 
Join Date: May 2019
Location: Alton
Posts: 1,982
M.O.C. #24086
Start with the 15A black self resetting fuse in the circuit breaker panel.
Swap it with a regular 15A blue fuse and try it again.
__________________
Daryl and Marianne,
2019 3130re 20th Anniversary Edition
2016 F350 Lariat
Daryles is offline   Reply With Quote
Old 11-11-2022, 10:01 AM   #5
raygreg
Seasoned Camper
 
Join Date: Apr 2019
Location: Renton
Posts: 61
M.O.C. #23813
I had a similar problem. Furnace would work and then not work etc.
I finally figured out the sail switch lever was hitting the surrounding fixed part and would not hit the switch every time.
I bent the lever with a needle nose pliers out and back (a sllght v) to clear the fixed object and trip the switch. It has been working for about 2 years now.
Sorry if this explanation is not very clear.
raygreg is offline   Reply With Quote
Old 11-23-2022, 06:25 PM   #6
plgavin
Established Member
 
Join Date: Aug 2018
Location: Colorado Springs
Posts: 10
M.O.C. #22393
I carry a multi-meter and alligator clip jumpers for trouble shooting things like this. Helps to sometimes narrow down the cause without as much disassembly. Cross connected the sail switch and tried again and then it worked, so looked at the switch and found junk on it.



Used these to figure why the gas side of the water heater wouldn't work by shorting the thermostat.
__________________
Paul and Penny Gavin
Black Forest CO
2018 330RL, 2015 Chevy 3500 diesel
plgavin is offline   Reply With Quote
Old 11-24-2022, 07:49 AM   #7
ChuckS
Montana Master
 
Join Date: Dec 2017
Location: Mountain Home
Posts: 667
M.O.C. #20949
Since you have an outside access panel for the furnace remove the panel and see if there is an error code that flashes on the control board when you try to start it..

If its actually running only 10 seconds that sounds like an issue with the black self resetting fuse Atwood loves to use..

If however the blower run time is longer than 10 seconds then stand outside at the furnace and have helper turn furnace on..

you should hear blower , then a ticking sound along with a whiff of propane..

If the furnace fails to ignite after 3 tries it goes into lockout mode. TO clear this simply turn thermostat off and back on.

I would highly suspect issue with sail switch if your blower runs and no ignition or propane smell

There is also a toggle switch located on the shiny metal case of the furnace.. cycle that off and on a few times as well when making your checks

Again.. look at that control board and note the number of flashes from the LED on the board..
ChuckS is offline   Reply With Quote
Old 11-24-2022, 07:20 PM   #8
badaxemi
Established Member
 
Join Date: Jan 2020
Location: Bad Axe
Posts: 23
M.O.C. #25648
Quote:
Originally Posted by Daryles View Post
Start with the 15A black self resetting fuse in the circuit breaker panel.
Swap it with a regular 15A blue fuse and try it again.
This solved my same issue this year. I tore the furance apart hoping to find a noticeable problem and even ordered a new board and all it was that damn 15A black self resetting fuse. GRRRRRRR.
badaxemi is offline   Reply With Quote
Old Yesterday, 11:26 AM   #9
Foldbak
Montana Master
 
Foldbak's Avatar
 
Join Date: Jan 2022
Location: Shingle Springs
Posts: 816
M.O.C. #30417
Quote:
Originally Posted by Daryles View Post
Start with the 15A black self resetting fuse in the circuit breaker panel.
Swap it with a regular 15A blue fuse and try it again.
Nailed it!
__________________
Tony & Donna
2022 Montana High Country 295RL, Solar Flex 400, Onan 3600 LPG, 2000 Dimensions inverter
2020 GMC Denali 2500 6.6 Duramax, Demco 21K Auto Slide
Foldbak is offline   Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by Montana RV, Keystone RV Company or any of its affiliates. This is an independent, unofficial site.


All times are GMT -6. The time now is 02:33 AM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2022, vBulletin Solutions, Inc.