|
08-08-2016, 08:43 AM
|
#1
|
Montana Master
Join Date: Jul 2013
Location: Aguanga
Posts: 606
M.O.C. #13601
|
Frame Flex need repair in MO/IN greater area?
So we are making our way across the country (currently in St Louis) and i'm 99.9% sure i've been bit by the frame flex gremlin. I've called keystone they directed me to a dealer up by them (Tiara RV) which if fine, i can make it there. But, the dealer is booked until October!
Does anybody know of a repair facility in this part of the country that can get me back on the road? All the dealers I call are booked for months.
edit: Found a dealer in Columbus OH (RCD) that can take me in and see what's going on. We have family close and it's fairly close to Pittsburgh where we have more family so I may be in luck!
|
|
|
08-08-2016, 12:48 PM
|
#2
|
Montana Master
Join Date: Oct 2013
Location: Ogden
Posts: 638
M.O.C. #13862
|
What is the "frame flex gremlin"???
|
|
|
08-08-2016, 01:35 PM
|
#3
|
Montana Master
Join Date: Jul 2013
Location: Aguanga
Posts: 606
M.O.C. #13601
|
Cracked and pulled away back of closet, front ODS outer wall from front of bed slide to front cap caulking pulling away and shifting when hitched/unhitched. if I recaulk when unhooked the bead ends up pushed up 1/4 inch once hooked up. if I recaulk when hooked up caulk is 1/4 inch too high off the needed location when unhooked.
|
|
|
08-08-2016, 01:48 PM
|
#4
|
Montana Master
Join Date: Sep 2013
Location: Pensacola (mail forward service)
Posts: 3,198
M.O.C. #13740
|
Hope it turns out okay in the long run. Bummer anyway you think about it. When one looks at a fifth wheel frame before the unit is built, it doesn't inspire a lot of confidence for me. The better frames equate to the gross weight being a lot more than 16k or so in my opinion. But we all have what we have and so much goes into if one will have an issue. John
__________________
2012 F350 6.7 L dually, 2013 3800RE with 6 pt leveling, Sumitomo 17.5" load range h tires, Samsung 18 cu ft residential fridge, 8k Morryde I.S. with disc brakes. Full timing since 2012.
|
|
|
08-08-2016, 05:45 PM
|
#5
|
Site Team
Join Date: Jun 2011
Location: Wilsey
Posts: 18,799
M.O.C. #11455
|
If you're coming west, you might try http://www.4seasonsrv.com They have been a Montana dealer for years, although they seem to be concentrating on other brands now. They took ours apart to check for frame flex last year and they have a camp ground right next door.
__________________
Dick, Joyce, Diego, Picatso and Gustav
2017 3720 RL, and 2013 HC 343RL
Pullrite Hitch, IS, Disk Brakes, 3rd AC, Winegard Traveler, Bathroom door mod, Dometic 320, couch for desk swap, replaced chairs, sun screens, added awnings, etc.
|
|
|
08-09-2016, 01:04 PM
|
#6
|
Montana Fan
Join Date: Nov 2010
Location: Chatsworth
Posts: 468
M.O.C. #10933
|
If you're in Taiga's area you're only about 40 miles from the Montana factory. They do repairs there during our MOC rally so I'd check in to the fairgrounds at Goshen,Indiana and go see them face to face. They often are very accommodating in person.
__________________
Gayle and John Devall
2017 Legacy 3720 IS and Disc brakes
1120 watts solar panels and 300 AH lithium batteries
2011 Ford f350 srw long box Lariat with B&W Patriot hitch. Residential Fridge.
|
|
|
08-09-2016, 01:30 PM
|
#7
|
Montana Master
Join Date: Jul 2010
Location: Lake Havasu City AZ.
Posts: 1,811
M.O.C. #10552
|
After my little run in with the low bridge, Taiga got me in in one day. Replaced the front AC and the Sat dish in at 7:30 AM out at 4:30 PM. Great people to work with. I paid the bill and dealt with the insurance latter.
__________________
Wayne and Ann Moore
2015 Ford F-350 King Ranch
Firestone air bags, bed saver.
Add 40 GAL tank in bed.
|
|
|
08-09-2016, 03:21 PM
|
#8
|
Montana Master
Join Date: Oct 2012
Location: Box Elder
Posts: 4,697
M.O.C. #12947
|
When we had ours repaired in May, we were fortunate to have found a mobile RV guy who is also a certified welder, and showed up at our campground site, the following morning after calling him. He spent the better part of the day, but completed the repairs, and we have no more frame movement. You might just start calling around, and doubt you will get so lucky as us finding one guy who does it all, but you might find one that has a contact with a welder that can do that part of the job.
__________________
Bob & Becky
2012 3402RL
2012 Chevy 2500HD D/A CC 4WD
|
|
|
08-09-2016, 05:47 PM
|
#9
|
Montana Master
Join Date: Jul 2013
Location: Aguanga
Posts: 606
M.O.C. #13601
|
We made it to Columbus OH w/o incident. Dropped the rig off at the dealer we contacted ahead of time. they were super friendly and accommodating. We discussed previous experiences they have had with fixing frames so I feel pretty confident they'll get the job done. Cap comes off tomorrow!
I would have loved to go direct to the factory but I was too concerned we would arrive and be turned away. Bird in the hand.
|
|
|
08-10-2016, 01:52 AM
|
#10
|
Montana Fan
Join Date: Oct 2006
Location: Friendship, Maine
Posts: 483
M.O.C. #6338
|
What is Taiga?
__________________
2012 Big Sky 3400, now an SOB 5th wheel
2007 Montana 3075 previously
2015 GMC 3500 Dually
|
|
|
08-10-2016, 07:26 AM
|
#11
|
Montana Master
Join Date: Aug 2012
Location: Northport
Posts: 624
M.O.C. #12724
|
Quote:
quote:Originally posted by davidaf
We made it to Columbus OH w/o incident. Dropped the rig off at the dealer we contacted ahead of time. they were super friendly and accommodating. We discussed previous experiences they have had with fixing frames so I feel pretty confident they'll get the job done. Cap comes off tomorrow!
I would have loved to go direct to the factory but I was too concerned we would arrive and be turned away. Bird in the hand.
|
Sure would love to see pictures of problem area with cap off.
__________________
Paul Northport,AL W4XH
2013 358 RLT Mountaineer
2008 Silverado Duramax
|
|
|
08-10-2016, 08:17 AM
|
#12
|
Site Team
Join Date: Jun 2011
Location: Wilsey
Posts: 18,799
M.O.C. #11455
|
Quote:
quote:Originally posted by Chip
What is Taiga?
|
It's Tiara. They're a local, high volume dealer in Elkhart near the Keystone plant. It's owned by a former Keystone Exec and are known for good service and good prices. Keystone frequently sends work there.
__________________
Dick, Joyce, Diego, Picatso and Gustav
2017 3720 RL, and 2013 HC 343RL
Pullrite Hitch, IS, Disk Brakes, 3rd AC, Winegard Traveler, Bathroom door mod, Dometic 320, couch for desk swap, replaced chairs, sun screens, added awnings, etc.
|
|
|
08-10-2016, 09:40 AM
|
#13
|
Montana Fan
Join Date: Oct 2006
Location: Friendship, Maine
Posts: 483
M.O.C. #6338
|
Ok, thanks. It's Tiara not Tiaga. I know Tiara. They are good.
__________________
2012 Big Sky 3400, now an SOB 5th wheel
2007 Montana 3075 previously
2015 GMC 3500 Dually
|
|
|
08-23-2016, 04:39 PM
|
#14
|
Montana Master
Join Date: Jan 2013
Location: Depends on temps
Posts: 1,648
M.O.C. #13157
|
Bought our rig @ Tiara. Sales is fine, service is a "0"
See our review in the service thread.
__________________
2012 Ram Laramie 3500 DRW 4x4 3.73 Tow Max Pkg B&W Companion 60 gal RDS aux fuel tank. 2014 Montana 3150RL, 2 A/C's, Leather, 6 Point Jacks, Splendede WD2100XC, Mor/ryde X-Factor, Duravis 250 tires with TST 507RV monitors. 2 x Honda EU2000's
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|