RV News RVBusiness 2021 Top 10 RVs of the Year, plus 56 additional debuts and must-see units → ×
 

Go Back   Montana Owners Club - Keystone Montana 5th Wheel Forum > MOC Technical Forums > Montana Problems, Problem Solving & Technical Help
Click Here to Login

Reply
 
Thread Tools Search this Thread Display Modes
 
Old 11-27-2020, 03:44 PM   #1
goodellj
Seasoned Camper
 
Join Date: Sep 2017
Location: Newington CT
Posts: 93
M.O.C. #20452
Furnace Problem and Solution

I had a problem in August when I tested my Atwood 8535-IV DCLP furnace, and today I had the same problem. Previously I fired up this propane furnace anticipating that I would need it some time over the following 2 months and it kept shutting of after about 60 seconds. The blower cleared the firebox for about 15 seconds, I got heat exhausted for about 5 seconds, then no heat for 5 seconds, then heat, no heat, heat, and then the furnace shut down and refused to run any more. I took the cover off, checked connections, blew out some dust, scratched my head, and tried it again and it was fine. And it worked fine when I needed it on that trip.

Fast forward to today when I took the Montana from storage and I had the same problem. Except it refused to work correctly no matter what I did. I took apart the blower, checked all the connections, and tried it again with the cover off. Same result. I noticed a blinking red light on the control board. Three red flashes, pause, then repeats, which means "Ignition lockout Fault". No clues in the owners manual on what this means, and not much in the manual for trouble shooting.

So I got on-line and googled "Ignition lockout Fault on an Atwood 8535-IV RV Furnace" and found lots of info. It was not the sail switch or a fuse. I was almost ready to order a new control board for $100. But one of the forum entries said that this error message could result from low propane pressure or air in the line.

There are a number of causes for these and some of them are typical of taking your camper out of storage. Turning on the propane too fast after being shut off in storage is a big one. This partially trips the runaway prevention valve on the propane tank. I fired up the stovetop burners and let them run for 10 minutes. I got excited because they were hard to light and there was air in the line, and the flame pulsed slightly (which I don't think it normally does). But it didn't fix the furnace problem.

Another solution is to shut the tanks off, and take the lines off the tanks, and then reconnect and s-l-o-w-l-y open the valves. If the runaway shutoff valve is partially tripped it would reset itself, and this solved my problem. It only took all afternoon, but at least my pipes won't freeze overnight. (Did I forget to mention that I purged the antifreeze from the water lines BEFORE I tested the furnace?)

Other solutions that worked for users in the forums were replacing the propane regulator because it might be bad, and replacing the control board.

I think it all comes down to inadequate propane flow, or maybe a bad control board erroneously sensing inadequate propane flow. I spent about 5 hours on this today and was really frustrated, but now it's fixed.
__________________
John & Janet from Connecticut
2012 Keystone Montana 3150RL
2012 Ford F350 Diesel 4x4 Lariat Crewcab SRW
goodellj is offline   Reply With Quote
Old 11-27-2020, 07:59 PM   #2
DQDick
Site Team
 
DQDick's Avatar
 
Join Date: Jun 2011
Location: Wilsey
Posts: 17,813
M.O.C. #11455
Thanks for posting, It's going to help more than a few other people.
__________________
Dick, Joyce, Diego, Picatso and Gustav
2017 3720 RL, and 2013 HC 343RL
2017 3500 Dodge Maxi DRW 4X4, Pullrite Hitch, IS, Disk Brakes, 3rd AC, Winegard Traveler, Bathroom door mod, Dometic 320, couch for desk swap, etc.
DQDick is offline   Reply With Quote
Old 11-28-2020, 07:07 AM   #3
jeffba
Montana Master
 
Join Date: Oct 2017
Location: Bastrop
Posts: 2,708
M.O.C. #20753
Yup A timely post for sure.
__________________
2019 20th Anniversary Edition 3701LK
B&W 20K for Ford OEM Puck
2018 Ford F-350 Lariat CCLB PSD DRW
Poke super lignum unum et diem
jeffba is offline   Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by Montana RV, Keystone RV Company or any of its affiliates. This is an independent, unofficial site.


All times are GMT -6. The time now is 03:12 AM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
×