|
|
02-09-2020, 05:44 AM
|
#1
|
Montana Fan
Join Date: Jan 2020
Location: Hilliards
Posts: 237
M.O.C. #25636
|
Backup water pump
I am looking to add a a back up water pump to my rig.
Why? When I fill the fresh water I feel as it abuses the installed pump and I don't want it to crap out when I get a shower!
I am going to add one to my auxiliary water transfer tank that I haul when we go boon docking. That way I can fill the fresh water tank via the city water connection. I want it to be possibly interchangable in case I have to replace the OEM one. Any Recommendations to a flow rate or particular brand?
Has anybody done this?
__________________
2020 MHC 330RL
2021 F350 DRW 6.7 Powerstroke
Retired and Rollin'!
|
|
|
02-09-2020, 06:37 AM
|
#2
|
Montana Master
Join Date: Aug 2009
Location: Grand Rapids
Posts: 1,896
M.O.C. #9561
|
I'm sure you raised a few eye brows on this one. You're in a new trailer.
I've been RVing since 2003 and have had lots of problems over the years but never a pump issue. I've never even thought about this an a possible issue.
Just google it and you'll find lots of options however.
Since you will do it anyway, just get the same pump you have in your new trailer...
|
|
|
02-09-2020, 08:06 AM
|
#3
|
Montana Fan
Join Date: Jan 2020
Location: Hilliards
Posts: 237
M.O.C. #25636
|
not sure if I want to stay with the OEM or upgrade to a 5GPM flow. Its only a few $$ more, but I think the cycling would be a lot less. Thus less wear. I'm just not sure if the higher flow rate would be interchangeable with the coaches plumbing. I do realize there would be fitting issues, I just wouldn't want to blow the lines apart!
__________________
2020 MHC 330RL
2021 F350 DRW 6.7 Powerstroke
Retired and Rollin'!
|
|
|
02-09-2020, 09:12 AM
|
#4
|
Montana Master
Join Date: Oct 2006
Location: McKinney
Posts: 7,167
M.O.C. #6433
|
I don't think a higher flow rate pump would reduce cycling. The pump normally turns on when flow starts, and doesn't turn off until flow stops and pressure in the line reaches a preset limit to stop the pump. Essentially one cycle per use. If anything, I suppose a higher flow pump could possibly cause an increase in pressure during low flow and cause the pump to cycle on and off during low flow.
From years of reading here, the pump is a low maintenance minimal problem item.
__________________
Bill & Patricia
Riley, our Golden
2007 3075RL (recently sold, currently without)
|
|
|
02-09-2020, 09:26 AM
|
#5
|
Site Team
Join Date: Jun 2011
Location: Wilsey
Posts: 18,799
M.O.C. #11455
|
I replaced the pump in the old rig with a higher flow rate one and didn't see enough difference to do it on this rig. 9 years of full timing and so far never a pump problem, but I do still have the OEM one from the old rig as a spare.
__________________
Dick, Joyce, Diego, Picatso and Gustav
2017 3720 RL, and 2013 HC 343RL
Pullrite Hitch, IS, Disk Brakes, 3rd AC, Winegard Traveler, Bathroom door mod, Dometic 320, couch for desk swap, replaced chairs, sun screens, added awnings, etc.
|
|
|
02-09-2020, 09:46 AM
|
#6
|
Montana Master
Join Date: Oct 2012
Location: Box Elder
Posts: 4,701
M.O.C. #12947
|
Instead of using an RV water pump to transfer water to the rig when dry camping, I use a Harbor Freight 12 volt pump and it has enough pressure at a very good flow rate to pump into the city water connection and is cheaper than a good RV pump. https://www.harborfreight.com/12v-dc...gph-63324.html
__________________
Bob & Becky
2012 3402RL
2012 Chevy 2500HD D/A CC 4WD
|
|
|
02-09-2020, 11:20 AM
|
#7
|
Montana Master
Join Date: Sep 2019
Location: lake stevens
Posts: 504
M.O.C. #24938
|
Like others have said the water pumps are very reliable components, if anything simply by a backup pump and install if ever needed, putting it inline (as a bypass) is just another place to leak.
|
|
|
02-09-2020, 11:28 AM
|
#8
|
Montana Master
Join Date: Jan 2017
Location: home base IL, OTR anywhere
Posts: 533
M.O.C. #19382
|
Having a spare water pump is something you don't need ....until you need it. Wiring in and plumbing in an aux water pump is peace of mind redundancy. I can see his point. I think I'd just carry the spare until I need it if I was going to go to the expense of getting one in the first place. Getting real world data on water pump failure rates would be the deciding criteria.
That is the NAVY storekeeper in me talking though.
__________________
2017 RAM 3500 Laramie CCLB Dually CTD Aisin, OEM auto level rear air-ride, B&W hitch
2020 3813MS Legacy Cobalt FBP, MORryde 8K IS & pinbox, PI EMS,DIY mods by in-house "craftsman", RV security system Mk1 Beagle Alerter
|
|
|
02-09-2020, 12:14 PM
|
#9
|
Montana Master
Join Date: Oct 2012
Location: Box Elder
Posts: 4,701
M.O.C. #12947
|
I think rarely do the motors fail, but more often it’s the diaphragms or valves inside the pump mechanism that fail or gets a bit of grit that stops the pumping action. It might be easier to carry a rebuild kit with all the pieces that can be replaced.
__________________
Bob & Becky
2012 3402RL
2012 Chevy 2500HD D/A CC 4WD
|
|
|
02-09-2020, 12:43 PM
|
#10
|
Montana Master
Join Date: Jan 2017
Location: home base IL, OTR anywhere
Posts: 533
M.O.C. #19382
|
hmmm 75-100 dollars for spare pump or 25-30 dollars for a repair kit. If repairing something is your thing I'd get the kit, if you want to get back into operation fairly quickly I'd go for the spare. Choose your poison.
__________________
2017 RAM 3500 Laramie CCLB Dually CTD Aisin, OEM auto level rear air-ride, B&W hitch
2020 3813MS Legacy Cobalt FBP, MORryde 8K IS & pinbox, PI EMS,DIY mods by in-house "craftsman", RV security system Mk1 Beagle Alerter
|
|
|
02-09-2020, 12:47 PM
|
#11
|
Montana Master
Join Date: Oct 2018
Location: Anderson
Posts: 2,590
M.O.C. #22835
|
No matter the flow rate of your water pump, you are still only going to get so much water out the spigot. The size of the water pipes and the restricted flow at the shower head, the kitchen sink and the aireator on it, will not permit any more water anyway.
The only problem I've ever had with a water pump in 21 years of RV ownership myself was when the screws wiggled loose on the pump diapharam and it let air suck in, causing the pump to cycle on and off for a split second ever 5 minutes or so.
But, as an FYI, here's what I use to transfer water from my auxiliary tank:
Here's the pump I'm using: Click Here. The reason I picked this one, which is a 120 v AC pump is because I have a 400 watt inverter I can hook up to any battery and run the pump.
But they do make one similar that is 12 volt DC only: Click here
The only down-side that might not work for your application is the fact, the pump runs all the time when powered up. It does not cycle on and off.
If you are wanting one that cycles on and off, you'd be better going with another RV water pump, perhaps one that is similar to yours already in the camper. It would need to be attached to the city in connection and then pressurized to keep it from running all the time. This would mimic being connected to a garden hose shore water.
__________________
Who you are right now is a sum total off all you use to be.
2019 Montana High Country 375FL
2014 Chevy Silverado Duramax, 6.6L Dually
|
|
|
02-09-2020, 02:05 PM
|
#12
|
Montana Fan
Join Date: Jan 2020
Location: Hilliards
Posts: 237
M.O.C. #25636
|
DutchmanSport, This is exactly what I had in mind! If my OEM pump ever quits, I could use this one to keep on camping! Thank you!
__________________
2020 MHC 330RL
2021 F350 DRW 6.7 Powerstroke
Retired and Rollin'!
|
|
|
02-09-2020, 02:12 PM
|
#13
|
Montana Master
Join Date: May 2017
Location: new caney
Posts: 1,050
M.O.C. #19873
|
Your original pump is probably noisy anyhow so why don't you just buy a shurflo pump which is much more quite and install it and save your old pump for a spare. This spare will probably never be needed but you can have a quite pump and peace of mind at the same time.
|
|
|
02-16-2020, 02:15 PM
|
#14
|
Established Member
Join Date: Sep 2018
Location: Eliot
Posts: 14
M.O.C. #22629
|
Tractor supply has pumps , I also brig a 12V supply to run it than recharge I installed a gauge to make sure the pressure wasn't and issue bout with the overflow a repair dealer said there shouldn't be an issue.
|
|
|
02-16-2020, 02:59 PM
|
#15
|
Established Member
Join Date: Mar 2019
Location: Isle of Palms
Posts: 42
M.O.C. #23714
|
The big deal with a higher flow pump is that you will use your limited supply of water faster.
|
|
|
02-16-2020, 03:51 PM
|
#16
|
Seasoned Camper
Join Date: Oct 2018
Location: Topeka
Posts: 95
M.O.C. #22922
|
I've been using a 35 gal stock tank and a 110v pump both from tractor supply for refilling our fresh water. On our very 1st trip in our new 2018 3811ms the water pump quit pumping, dealer gave us a new one, but didnt want the old one. I tinkered with it and got it to work again. Turns out I did something wrong and needed to prime the pump to get it to pump water.
I now carry this same pump as a back up because there is nothing more miserable than a pump quitting mid shower.
__________________
Steve & Ginger Patterson
2018 Montana 3811 MS
2018 GMC Denali 3500 HD Duramax
|
|
|
02-16-2020, 03:56 PM
|
#17
|
Montana Fan
Join Date: Feb 2020
Location: Hawkins - Tx
Posts: 142
M.O.C. #25774
|
Quote:
Originally Posted by BiggarView
Having a spare water pump is something you don't need ....until you need it. Wiring in and plumbing in an aux water pump is peace of mind redundancy. I can see his point. I think I'd just carry the spare until I need it if I was going to go to the expense of getting one in the first place. Getting real world data on water pump failure rates would be the deciding criteria.
That is the NAVY storekeeper in me talking though.
|
We had a 1997 NuWa Hitchhiker II and never had a problem with the pump except when I forgot the pressure regulator (oops) and the hose clamp leaked on the pump. I think this would be way down on my ‘what if’ list.
__________________
Gunther, Sheri and Calvin
2020 Montana 3812 MS with a Reese Goosebox
2006 Dodge 3500 Dually, LB, 6 Sp, 5.9 Cummins with Flashpaq Super Chip Tuner
South Bend Flywheel and Clutch, Loadlifter 5000 Rear Air Bag Kit
|
|
|
02-16-2020, 04:23 PM
|
#18
|
Montana Master
Join Date: Dec 2005
Location: Eugene
Posts: 1,053
M.O.C. #5091
|
Fresh water tank filling up on its own
Had this same problem several years ago. The fresh water tank fills up even though lever is turned as to not fill tank. Took it too dealership at the time and they could not find the problem. Several people on the forum said it could be the stock water pump. Bought a new Shur-Flo pump and stopped the problem. This winter as I drained the system the fresh water tank continued to drain for about 1/2 hour, so I know the tank is filling up again after being hooked up to city water. Don't care to be hauling several hundred pounds of extra weight when I don't need the water. Are the check valves in the pump not doing their or what?
|
|
|
02-16-2020, 04:53 PM
|
#19
|
Montana Master
Join Date: Dec 2007
Location: Kansas City, Missouri
Posts: 2,707
M.O.C. #7992
|
Quote:
Originally Posted by Jeff Myers
not sure if I want to stay with the OEM or upgrade to a 5GPM flow. Its only a few $$ more, but I think the cycling would be a lot less. Thus less wear. I'm just not sure if the higher flow rate would be interchangeable with the coaches plumbing. I do realize there would be fitting issues, I just wouldn't want to blow the lines apart!
|
Don't think you have to worry about blowing the lines apart. Pressure is the psi the pump will deliver. GPM is the volume of water the system will deliver. They increase the volume by using larger impellers on the pump without increasing the pressure.
__________________
2006 3000RK
2009 Ram 2500
|
|
|
02-16-2020, 09:43 PM
|
#20
|
Montana Fan
Join Date: Jul 2018
Location: Islip Terrace
Posts: 405
M.O.C. #22165
|
Quote:
Originally Posted by BB_TX
I don't think a higher flow rate pump would reduce cycling. The pump normally turns on when flow starts, and doesn't turn off until flow stops and pressure in the line reaches a preset limit to stop the pump. Essentially one cycle per use. If anything, I suppose a higher flow pump could possibly cause an increase in pressure during low flow and cause the pump to cycle on and off during low flow.
From years of reading here, the pump is a low maintenance minimal problem item.
|
Easy way to reduce cycling would be to add an accumulator tank after the pump. A 2 gal one would reduce cycling & quiet the pump, on my upgrade list for this year.
|
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|