|
|
08-11-2018, 08:39 PM
|
#1
|
Montana Fan
Join Date: Aug 2017
Location: Vineland
Posts: 135
M.O.C. #20374
|
Generator Exhaust
I have a new 2018 Montana 3731FL and purchased with out a generator.We don’t usually boondock but considering buying a Champion 3500 dual fuel remote inverter generator for when traveling and stopping at nights.My concern is venting the exhaust when mounted in the front compartment meant for a generator.
Anyone familiar with the setups and pros and cons?
|
|
|
08-11-2018, 09:11 PM
|
#2
|
Montana Master
Join Date: Jan 2018
Location: Thornville
Posts: 546
M.O.C. #21110
|
IF I was to use a portable generator setup,I would NOT use it in the front generator compartment. I would find a way to secure it outside, attached to the coach or tow vehicle.
__________________
Darwin & Carla
2018.5 3701LK Montana
2022 3500HD Denali Duramax SRW
|
|
|
08-11-2018, 09:16 PM
|
#3
|
Site Team
Join Date: Sep 2017
Location: Oro Valley
Posts: 3,933
M.O.C. #20477
|
I would recommend against mounting it internal. Unless you have the correct mounting set up, you will have a fair amount of noise and vibration. If you want to go internal, bite the bullet for an OEM setup.
You could mount a portable genny in the back of your truck or set it out. Your Champion 3500 will run 1 a/c.
We added 4 6 volt golf cart batteries, a 3000 watt inverter and 550 watts of solar. We also have 2 2000 watt Honda generators that will allow us to run 1 a/c or recharge our battery bank if we have a lot of cloud cover.
__________________
Zack and Donna plus Millie and Ranger
2018 3160RL
"Life is too short to stay indoors, enjoy the ride!"
|
|
|
08-11-2018, 09:35 PM
|
#4
|
Montana Fan
Join Date: May 2018
Location: san andreas
Posts: 209
M.O.C. #21805
|
yes. mount your non factory gen outside.
even in a shortbed truck it can be bolted down ( honda eu3000). so no way will it walk away.
or bolted to a rear rack. that is also secured very well to your coach.
just rig up a way to hold two metal gas can on the rack. one each side of the gen ( blance thing). and a truck grade tarp to cover in bad weather or while in transit.
belife of not seen, can not "walk away".
|
|
|
08-12-2018, 08:53 AM
|
#5
|
Site Team
Join Date: Jun 2011
Location: Wilsey
Posts: 18,799
M.O.C. #11455
|
I'll join the group that feel you should only put a generator in that compartment that was meant to go there. Exhaust, heat transfer, engine cooling and electrical issues are all a part of the consideration.
__________________
Dick, Joyce, Diego, Picatso and Gustav
2017 3720 RL, and 2013 HC 343RL
Pullrite Hitch, IS, Disk Brakes, 3rd AC, Winegard Traveler, Bathroom door mod, Dometic 320, couch for desk swap, replaced chairs, sun screens, added awnings, etc.
|
|
|
08-12-2018, 11:02 AM
|
#6
|
Montana Master
Join Date: Aug 2009
Location: Grand Rapids
Posts: 1,896
M.O.C. #9561
|
PUT OUTSIDE!!!!!do not put a non approved external generator in the RV. people die
|
|
|
08-13-2018, 07:29 PM
|
#7
|
Montana Fan
Join Date: Jun 2018
Location: Holladay
Posts: 209
M.O.C. #22087
|
Quote:
Originally Posted by mazboy
PUT OUTSIDE!!!!!do not put a non approved external generator in the RV. people die
|
DITTO. Secure it outside.
__________________
2019 HC 381TH
2021 Ram 3500 6.7 HO
|
|
|
08-14-2018, 05:19 AM
|
#8
|
Montana Master
Join Date: Mar 2013
Location: Hanover
Posts: 1,471
M.O.C. #13325
|
Quote:
Originally Posted by DQDick
I'll join the group that feel you should only put a generator in that compartment that was meant to go there. Exhaust, heat transfer, engine cooling and electrical issues are all a part of the consideration.
|
Ditto. Only issue is unhooking and pulling forward about ten feet to get the exhaust away from the front of your 5er. A Wallymart 30 amp extension cord works fine.
|
|
|
08-14-2018, 07:57 AM
|
#9
|
Montana Master
Join Date: Aug 2015
Location: SWFL
Posts: 964
M.O.C. #17801
|
Portable gender, always outside, never in. Also, try to locate it so exhaust blows away from your unit.
__________________
2016 Montana 3711FL
2005 Ford F350, 6.0 diesel, short bed
Demco Hitchiker Auto Slide hitch
|
|
|
08-19-2018, 01:51 PM
|
#10
|
Established Member
Join Date: Feb 2012
Location: Idaho Falls
Posts: 19
M.O.C. #12224
|
I posted installing a Honda 6500 on slide out bars utilizing the gen prep transfer switch but removing the aluminum box. The post was under Additions and Improvements and Honda 6500 installation. It was posted 12/13/2013 and had pics of the whole thing. I am still using the setup and it works out great for me...and no exhaust problems. At least gives you an idea of other installation possibilities.
|
|
|
08-19-2018, 03:01 PM
|
#11
|
Seasoned Camper
Join Date: Oct 2010
Location: Simi Valley
Posts: 71
M.O.C. #10801
|
I use a Honda 2000 in the front compartment on a slide out tray (mor ride ) welded a nipple on the exhaust with a 90 ELL A length of heater hose to a length of conduit to exhaust fumes out left side of trailer under the front When done with gen. Disconnect heater hose and push gen. Into compartment.
|
|
|
08-19-2018, 04:39 PM
|
#12
|
Montana Fan
Join Date: Aug 2017
Location: Vineland
Posts: 135
M.O.C. #20374
|
Quote:
Originally Posted by USNSS
I posted installing a Honda 6500 on slide out bars utilizing the gen prep transfer switch but removing the aluminum box. The post was under Additions and Improvements and Honda 6500 installation. It was posted 12/13/2013 and had pics of the whole thing. I am still using the setup and it works out great for me...and no exhaust problems. At least gives you an idea of other installation possibilities.
|
I looked back and saw the photos of your install.
Nice job and gives me something to think about.
Thanks.
|
|
|
08-20-2018, 12:26 AM
|
#13
|
Montana Master
Join Date: Nov 2012
Location: Rancho Santa Margarita
Posts: 633
M.O.C. #13025
|
Chapman, do you have photos of your install? i have a slide out tray but haven't figured out the exhaust reroute.
__________________
Russ and Linda, So. California
2004 Chevy Silverado 2500 HD, D/A, SRW, SB
2005 2955RL, Pullrite Superglide 16K hitch. Bridgestone Duravis R500 tires. EZ Flex Equilizers with wet bolts.EMS HW50C, Disk brakes
|
|
|
08-20-2018, 07:45 AM
|
#14
|
Seasoned Camper
Join Date: Oct 2010
Location: Simi Valley
Posts: 71
M.O.C. #10801
|
Gen. Exhaust
Quote:
Originally Posted by h2ojocky
Chapman, do you have photos of your install? i have a slide out tray but haven't figured out the exhaust reroute.
|
Yes but not sure how to send them !!
|
|
|
08-20-2018, 07:47 AM
|
#15
|
Seasoned Camper
Join Date: Oct 2010
Location: Simi Valley
Posts: 71
M.O.C. #10801
|
Quote:
Originally Posted by chapman
Yes but not sure how to send them !!
|
send me your e mail address I know how to do that !
|
|
|
08-20-2018, 10:45 AM
|
#16
|
Montana Master
Join Date: Nov 2012
Location: Rancho Santa Margarita
Posts: 633
M.O.C. #13025
|
Chapman I sent you a PM
__________________
Russ and Linda, So. California
2004 Chevy Silverado 2500 HD, D/A, SRW, SB
2005 2955RL, Pullrite Superglide 16K hitch. Bridgestone Duravis R500 tires. EZ Flex Equilizers with wet bolts.EMS HW50C, Disk brakes
|
|
|
08-20-2018, 10:59 AM
|
#17
|
Seasoned Camper
Join Date: Mar 2018
Location: Stark City
Posts: 89
M.O.C. #21339
|
Our 3121RL has a rear receiver hitch. I utilized a hitch haul platform that inserts in the receiver hitch. We welded a rail system that keeps two 3500 watt generators secure on the platform and also has a locking bar across the top that prevents anyone from removing the generators. It allows for easy plug in and servicing while keeping the generators far enough away from the bedroom. You can't even hear them running in the bedroom or in the living area if the air is running.
__________________
Indian Springs Farm
2018 3121RL Samsung Residential Fridge
2018 Ford F250 PSD Air Lift 5000
Sailun 637 tires Predator 3500 (2) paralleled
|
|
|
08-20-2018, 11:06 AM
|
#18
|
Montana Master
Join Date: Oct 2017
Location: Bastrop
Posts: 2,892
M.O.C. #20753
|
In the truck forums they say you did not do it unless you post a pic. Here we just ask nicely if you please post a pic. Thanks
__________________
Mocha, one-eyed toothless, hurricane survivor, Pirate dog
2019 20th Anniversary Edition 3701LK
B&W 20K for Ford OEM Puck
2018 Ford F-350 Lariat CCLB PSD DRW KJ5CQH
|
|
|
08-21-2018, 01:54 PM
|
#19
|
Montana Master
Join Date: Nov 2012
Location: Rancho Santa Margarita
Posts: 633
M.O.C. #13025
|
Chapman I sent you a private message.
__________________
Russ and Linda, So. California
2004 Chevy Silverado 2500 HD, D/A, SRW, SB
2005 2955RL, Pullrite Superglide 16K hitch. Bridgestone Duravis R500 tires. EZ Flex Equilizers with wet bolts.EMS HW50C, Disk brakes
|
|
|
08-21-2018, 06:49 PM
|
#20
|
Seasoned Camper
Join Date: Jul 2016
Location: Santa Rosa Beach
Posts: 60
M.O.C. #18757
|
Generator
We have a similar generator mounted on an aluminum cargo carrier on the back of our Monty.
Drilled holes in the generator cage and bolted it down.
I bought a champion fabric cover for it. They only last about a year. I built an exterior snug fitting plywood flat "top" that fits over the top of the generator that can be put over it when needed so I can run it in the rain when we are stopped.
We can park virtually anywhere with this setup.
You can't hear the generator when inside when the windows are closed. No exhaust gets inside either.
But, we have 3 monoxide detectors inside too.
Maybe overkill, but we can sleep well.
|
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|