![Reply](/forums/images/mo/buttons/reply.gif) |
|
04-12-2018, 10:56 AM
|
#1
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
Breaker panel/converter/inverter
When hooking my 7000w Honda generator to my camper to run the slides out and put some stuff away, apparently I wired my power supply cable wrong and a little bit of smoke came out of breaker panel. I immediately unplugged trailer. I do not have battery power to microwave, TV's, or ceiling fan. Checked all breakers and fuses, no luck. Lights, slides and everything seems to work. First brand new camper ever. Did I screw up bad? I haven't checked all the GFCI's yet.
|
|
|
04-12-2018, 11:21 AM
|
#2
|
Montana Master
Join Date: Oct 2006
Location: McKinney
Posts: 7,172
M.O.C. #6433
|
Your microwave, ceiling fan, and (most likely) TVs are powered from 120 vac, not battery. Do you have 120 vac to any outlets in the trailer?
Tripped circuit breakers are not immediately apparent at a glance. The handle does not flip to the OFF side, just moves slightly off of the ON side and will feel “soft” if pressed. You must turn them off and back on to reset.
__________________
Bill & Patricia
Riley, our Golden
2007 3075RL (recently sold, currently without)
|
|
|
04-12-2018, 12:58 PM
|
#3
|
Montana Master
Join Date: May 2011
Location: Hixson
Posts: 3,436
M.O.C. #11397
|
I would be more concerned about the smoke. If you did have 12v to your microwave, tv (s), and ceiling fan you would REALLY have a problem as they operate on 120v only.
__________________
2018.5 Montana 3791RD
Full Timers 9/1/2010 through 1/16/2020.
|
|
|
04-12-2018, 04:54 PM
|
#4
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
Battery drain
I pulled the batteries out of my brand new rv charged them and had them load tested. All was good, we were able to operate slides and all with no problem. I opened the battery disconnects before leaving and came back 24 hours later and batteries are dead. Any ideas? Help, I’m stumped. This is another problem of course.
|
|
|
04-12-2018, 05:16 PM
|
#5
|
Montana Master
Join Date: Nov 2015
Location: Arlington
Posts: 1,522
M.O.C. #18081
|
As others have said those loads you mentioned run off of 12v rather than 120v. When you replaced the batteries did you turn the disconnect back on? Also which output from your generator did you feed your coach with?
__________________
SOB
2015 Volvo VNL780 D13, iShift, 32k ET air hitch, Idle Free LiFePO4 APU
16.8KWhr LiFePO4, 2.52 kw solar, 10kva Victron split phase
|
|
|
04-12-2018, 05:40 PM
|
#6
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
I have 2 Honda 2200 generators in parallel. I’m using the rv shore cord with the dog bone which in turn went into the 30 amp twist lick on the generator. I’m also trying to figure out why my batteries will not stay charged over 24 hours even with both disconnects open. What else could there be to draw from.
|
|
|
04-12-2018, 05:58 PM
|
#7
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
Battery
Yes I did close disconnect.
|
|
|
04-12-2018, 05:58 PM
|
#8
|
Montana Master
Join Date: Jan 2018
Location: Thornville
Posts: 546
M.O.C. #21110
|
What model is your camper? That would help if you added that info to your signature so all would know what unit you have when you ask questions.
Does it have the residential fridge?
__________________
Darwin & Carla
2018.5 3701LK Montana
2022 3500HD Denali Duramax SRW
|
|
|
04-12-2018, 06:26 PM
|
#9
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
2018 3731 FL residential fridge, six slides.
|
|
|
04-12-2018, 06:31 PM
|
#10
|
Montana Master
Join Date: Jan 2018
Location: Thornville
Posts: 546
M.O.C. #21110
|
The residential fridge WILL draw the batteries down within a day or so if not connected to shore power or a tow vehicle, so I`m told by 2 different dealers. I have NOT tested their claim myself, just what I was told.
__________________
Darwin & Carla
2018.5 3701LK Montana
2022 3500HD Denali Duramax SRW
|
|
|
04-12-2018, 06:33 PM
|
#11
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
Fridge
It has its own separate disconnect.
|
|
|
04-12-2018, 06:35 PM
|
#12
|
Montana Fan
Join Date: Jun 2016
Location: Reno
Posts: 140
M.O.C. #18681
|
Many years ago my husband didn't get the plug in the power pedestal all the way and it came out, arced and there was a small puff of smoke and a slight electrical burn smell.
Unfortunately, it blew out our microwave, 2 TVs and our stereo unit. Our slides and lights worked for about a day then the batteries went low and we lost everything. Apparently by shorting out the shore power line we blew the converter! Simple fix but we had to buy and install a new converter.
Hope yours isn't as bad. Good luck!
__________________
Marsha& Kirk
2016 3160RL, 2002 Ford F350 Turbo Diesel
Rudy & Roxy, mini dachshunds
|
|
|
04-12-2018, 06:37 PM
|
#13
|
Montana Master
Join Date: Sep 2013
Location: Pensacola (mail forward service)
Posts: 3,198
M.O.C. #13740
|
What "power supply cable" did you wire up? Your 7:40 comment makes no mention of any special wiring?
__________________
2012 F350 6.7 L dually, 2013 3800RE with 6 pt leveling, Sumitomo 17.5" load range h tires, Samsung 18 cu ft residential fridge, 8k Morryde I.S. with disc brakes. Full timing since 2012.
|
|
|
04-12-2018, 06:53 PM
|
#14
|
Montana Master
Join Date: Jan 2018
Location: Thornville
Posts: 546
M.O.C. #21110
|
Quote:
Originally Posted by sharpbob1
It has its own separate disconnect.
|
Yes it is located in the front cargo area with the batteries...the other disconnect is located in the convenience compartment.
__________________
Darwin & Carla
2018.5 3701LK Montana
2022 3500HD Denali Duramax SRW
|
|
|
04-12-2018, 06:55 PM
|
#15
|
Montana Master
Join Date: Jan 2018
Location: Thornville
Posts: 546
M.O.C. #21110
|
Quote:
Originally Posted by jcurtis934
What "power supply cable" did you wire up? Your 7:40 comment makes no mention of any special wiring?
|
Good question.....maybe they made their own generator power supply cord. I made my own for my TT`s that I had prior to this 5er.
__________________
Darwin & Carla
2018.5 3701LK Montana
2022 3500HD Denali Duramax SRW
|
|
|
04-12-2018, 07:11 PM
|
#16
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
Power cord
I made a cord at work with help from my electrical department.
|
|
|
04-12-2018, 07:15 PM
|
#17
|
Montana Master
Join Date: Nov 2015
Location: Arlington
Posts: 1,522
M.O.C. #18081
|
I am keying in on the fact that you said there was some smoke from your converter/power dist unit. If there is no output from the charger that might explain the batteries not holding a charge. When you plugged in the generator were there loads connected? In other words perhaps you drew an arc when plugging in with the loads connected and the gen output on.
__________________
SOB
2015 Volvo VNL780 D13, iShift, 32k ET air hitch, Idle Free LiFePO4 APU
16.8KWhr LiFePO4, 2.52 kw solar, 10kva Victron split phase
|
|
|
04-13-2018, 06:05 AM
|
#18
|
Montana Master
Join Date: May 2011
Location: Hixson
Posts: 3,436
M.O.C. #11397
|
Quote:
Originally Posted by sharpbob1
When hooking my 7000w Honda generator to my camper to run the slides out and put some stuff away, apparently I wired my power supply cable wrong and a little bit of smoke came out of breaker panel. I immediately unplugged trailer. I do not have battery power to microwave, TV's, or ceiling fan. Checked all breakers and fuses, no luck. Lights, slides and everything seems to work. First brand new camper ever. Did I screw up bad? I haven't checked all the GFCI's yet.
|
Quote:
Originally Posted by sharpbob1
I have 2 Honda 2200 generators in parallel. I’m using the rv shore cord with the dog bone which in turn went into the 30 amp twist lick on the generator. I’m also trying to figure out why my batteries will not stay charged over 24 hours even with both disconnects open. What else could there be to draw from.
|
![Confused](images/smilies/confused.gif) Which are you using.....the 7000w Honda or the 2 Hondas in parallel?
__________________
2018.5 Montana 3791RD
Full Timers 9/1/2010 through 1/16/2020.
|
|
|
04-13-2018, 09:03 AM
|
#19
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
7000 originally but I sold it and bought the two 2200 suitcase models because they were easy to handle
|
|
|
04-13-2018, 09:06 AM
|
#20
|
Established Member
Join Date: Apr 2018
Location: PONCA CITY
Posts: 13
M.O.C. #21548
|
also do you think its a good idea to put a disconnect on the ground cable? I've read several threads where people did that to ensure no draw of power when idle
|
|
|
![Reply](/forums/images/mo/buttons/reply.gif) |
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|