Go Back   Montana Owners Club - Keystone Montana 5th Wheel Forum > MOC on M.A.R.S. > Montana Problems, Problem Solving & Technical Help
Click Here to Login

Reply
 
Thread Tools Display Modes
 
Old 11-06-2006, 03:03 PM   #1
genecurp
Montana Fan
 
Join Date: Nov 2004
Location: Nashville
Posts: 290
M.O.C. #2535
roof scuff

I found a scuff or scratch in my rubber roof up near the new vent cover installed by my dealer. How the scratch got there is another subject. The question now is "What should be done to protect the roof?"

This scratch is shallow, and does not cut thru the roof membrane. It is about 3 inches long. I am not inclined to do nothing. I am considering covering with EternalBond tape. Is that wise, or is another patch a better approach.

My unit is only 1 year old, so this repair will need to hold many years.

Thanks for your input.
genecurp is offline   Reply With Quote
Old 11-06-2006, 04:19 PM   #2
ols1932
Montana Master
 
Join Date: Aug 2004
Location: Cedar Rapids
Posts: 4,876
M.O.C. #1944
I'd cover it with a piece of Eternabond roofing tape. You can pick up kits at almost any RV service place but it's expensive when you buy it that way. I buy mine from http://bestmaterials.com/roof_repair.aspx and keep a whole roll handy. On my living room slide roof it appeared that the line of screw heads close to the outside panel were wearing through the roofing material so I put three strips of Eternabond the full length of the slide roof, overlapping each strip about 1/2 inch. I also fixed a couple of "scuffs" on my roof the same way with just one short strip. Incidentally, I also placed a strip on the roof where the antenna end rests on the roof just to keep from wearing a spot in the roofing.

Be sure when you go to put the strips on the roof that you clean the area well with just plain rubbing alcohol. Make sure your strip is cut the length you want it and when you get ready to put it down realize that when you stick it down, it sticks! You can't move it!

Orv
ols1932 is offline   Reply With Quote
Old 11-12-2006, 01:32 AM   #3
genecurp
Montana Fan
 
Join Date: Nov 2004
Location: Nashville
Posts: 290
M.O.C. #2535
Thanks for the input. My dealer found the scuff was from the TV antenna when in the down position vibrating and touching the roof. The service tech said to watch it, that the spot doesn't need patching yet. I plan to install a piece of Eternal Bond tape, but first I am having a UV treatment put on the roof the the washing vendor here at my campground.

Happy travels

genecurp is offline   Reply With Quote
Old 11-12-2006, 01:43 AM   #4
Glenn and Lorraine
Montana Master
 
Join Date: Jul 2003
Location: Clearwater
Posts: 10,917
M.O.C. #420
The white of the roof is just a cosmetic thing and it's only real purpose is appearance and also reflects the suns heat. ALL rubber is black and our roofs are no different. If you could look under the white you will find the black membrane. In short, If you don't see BLACK than I would not be at all concerned and would leave well enough alone. Remember anything you do to your rubber roof could adversely effect your 10 year roof warranty.
Glenn and Lorraine is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
New roof! Old GI Repairs & Service 8 02-11-2007 08:05 AM
roof gbsb Montana Problems, Problem Solving & Technical Help 4 04-04-2006 10:13 PM
Little Rip In My Roof-Now What Sue Montana Problems, Problem Solving & Technical Help 11 10-24-2005 08:26 PM
Cleaning roof/slide roof 2007dura It's a Dirty Job but Someone has to do it! 10 04-18-2005 02:02 AM
Going on roof BandJ General Discussions about our Montanas 17 08-18-2004 05:05 PM

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by Montana RV, Keystone RV Company or any of its affiliates. This is an independent, unofficial site.


All times are GMT -6. The time now is 04:54 PM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2018, vBulletin Solutions, Inc.