|
11-30-2016, 02:52 PM
|
#1
|
Montana Master
Join Date: Apr 2016
Location: North Lake Tahoe
Posts: 639
M.O.C. #18510
|
Dodge RAM 3500 freezing up?
I have had my Ram 3500 long bed dually out in the elements for the last week, where the days had highs of 36 degrees, and lows of 17 degrees. So we drove to Reno today for about 3 hours in 45 degree temps, and after about 2.5 hours, the windshield washer fluid finally worked, but then I noticed a strong diesel smell, that I otherwise never smell from these new trucks, and I was wondering if the DEF tank also froze up, and was not doing it's job correctly? Any thoughts on this?
__________________
2017 3820FK Legacy Edition full body paint Montana, For Sale this November, 2018. 2016 Ram 3500 long bed Dually Cummins Turbo with air bags
|
|
|
11-30-2016, 03:42 PM
|
#2
|
Montana Master
Join Date: May 2016
Location: Cuyahoga Falls
Posts: 699
M.O.C. #18572
|
As far as the washer fluid goes, use de-icer washer fluid. Good to -25. DEF fluid can freeze but the tank for that should have a heater. At least my Ford does. As for the "diesel" smell, fuel not being burned completely. Possible fuel gelling, but don't think your temps are cold enough for that. Could try a cetane booster with antigelling agents fuel additive.
JMHO
__________________
ATC/NAC Jerry A. Burkholder, USN (RET.)
Rule #1. The Chief is always right.
Rule #2. When in doubt, refer to rule #1.
|
|
|
11-30-2016, 04:40 PM
|
#3
|
Montana Master
Join Date: Jan 2016
Location: STAYTON
Posts: 1,118
M.O.C. #18157
|
I don't think there's any way your fuel gelled at 45* I've been down close to 0 with no issue.
Mark
__________________
“Hard times create strong men, strong men create good times, good times create weak men, and weak men create hard times.”
|
|
|
11-30-2016, 04:51 PM
|
#4
|
Montana Master
Join Date: May 2016
Location: Cuyahoga Falls
Posts: 699
M.O.C. #18572
|
Quote:
quote:Originally posted by MARK A
I don't think there's any way your fuel gelled at 45* I've been down close to 0 with no issue.
Mark
|
Nothing personal Mark, his low temps were 17 degrees. I only suggested gelling as a possibility but didn't think those temps were cold enough. I only mentioned the additive as a prevention.
Again, nothing personal. JMHO
__________________
ATC/NAC Jerry A. Burkholder, USN (RET.)
Rule #1. The Chief is always right.
Rule #2. When in doubt, refer to rule #1.
|
|
|
12-01-2016, 05:48 AM
|
#5
|
Seasoned Camper
Join Date: Jan 2014
Location: Apache Junction AZ
Posts: 54
M.O.C. #14022
|
That smell is the engine going through the cycle to clean out the exhaust system .
Tom Happy Camping#128526;
|
|
|
12-01-2016, 09:05 AM
|
#6
|
Seasoned Camper
Join Date: Jun 2016
Location: Havelock
Posts: 70
M.O.C. #18670
|
I agree with Tom. The truck went into a re gen mode to clean out the exhaust filter. This will happen every so often and on a RAM it should put a message on the info center saying it has started.
__________________
Dennis & Debbie Henry Havelock.NC
2018 3791RD ,2016 RAM 3500 DRW
|
|
|
12-01-2016, 10:57 AM
|
#7
|
Montana Master
Join Date: Apr 2016
Location: North Lake Tahoe
Posts: 639
M.O.C. #18510
|
Cool to know about the exhaust cleaning cycle, I had no idea it did this. Today i started it at 25 degrees, and you could put your nose right up to the exhaust pipe. It has a faint bleach type smell. Thanks for the tips. I use straight water in my windshield reservoir, because I use Rain-X on my windshield. Does the anti-freeze smear up the windows if you are using rain-X? If not, then I will definitely start mixing it in. Thanks
__________________
2017 3820FK Legacy Edition full body paint Montana, For Sale this November, 2018. 2016 Ram 3500 long bed Dually Cummins Turbo with air bags
|
|
|
12-01-2016, 02:22 PM
|
#8
|
Seasoned Camper
Join Date: Jul 2016
Location: new caney
Posts: 98
M.O.C. #18819
|
You shouldn't have any problem with the wiper fluid being mixed with rain-x. Just be sure to add enough of the low temperature wiper fluid to give you plenty of freeze protection. If your protection is 32 degrees and your new wiper fluid is -25 degrees then a 50/50 mix would put you at about + 3 DEGREES. Any colder than that and i'm staying home lol.
|
|
|
12-01-2016, 10:42 PM
|
#9
|
Montana Fan
Join Date: Jun 2008
Location: Greenport
Posts: 216
M.O.C. #8571
|
use the RainX washer fluid works great.
|
|
|
12-02-2016, 01:00 AM
|
#10
|
Montana Master
Join Date: May 2011
Location: Hixson
Posts: 3,436
M.O.C. #11397
|
Quote:
quote:Originally posted by Tfthorp
use the RainX washer fluid works great.
|
I also use this.
__________________
2018.5 Montana 3791RD
Full Timers 9/1/2010 through 1/16/2020.
|
|
|
12-02-2016, 03:59 AM
|
#11
|
Montana Master
Join Date: Oct 2004
Location: Salem
Posts: 7,550
M.O.C. #2283
|
I have RainX washer fluid but it's only good to 32 degrees so be careful with that.
Lynwood
|
|
|
12-02-2016, 06:40 AM
|
#12
|
Montana Master
Join Date: Oct 2006
Location: McKinney
Posts: 7,167
M.O.C. #6433
|
RainX comes in different flavors, including All Season good to -25.
__________________
Bill & Patricia
Riley, our Golden
2007 3075RL (recently sold, currently without)
|
|
|
12-04-2016, 05:43 PM
|
#13
|
Seasoned Camper
Join Date: Jul 2016
Location: new caney
Posts: 98
M.O.C. #18819
|
I have noticed when traveling that the Wal-marts in the deep south like where i am in Texas has only 32 degree wiper fluid and pretty well anywhere north it is 0 degrees or less.
|
|
|
03-20-2017, 06:36 PM
|
#14
|
Established Member
Join Date: Mar 2017
Location: Thunder Bay
Posts: 20
M.O.C. #19503
|
Don't know if you got to the bottom of this, but your def pump froze. Exact same thing and observations when mine went at slightly colder temps three weeks later than yours. My buddy is the cummins tech at the dealer and he said dozens of 2016s came in during January....all with failed def pumps. Hope yours is ok...maybe have them check the codes in case it's a bad one and get replaced while under warranty.
__________________
-----------------------
2010 3665RE
2017 3810MS
2016 Dodge Ram 6.7 Cummins, 6" BDS Lift on 37" Toyo MTs
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
Similar Threads
|
Thread |
Thread Starter |
Forum |
Replies |
Last Post |
3500 Dodge Towing
|
jlb27537 |
Tow Vehicles & Towing |
8 |
01-29-2013 12:34 AM |
Dodge 3500
|
pathfinder |
Tow Vehicles & Towing |
15 |
06-03-2010 02:33 PM |
Dodge 4x4 3500 owners?
|
j_a_wolfe |
Tow Vehicles & Towing |
7 |
07-30-2009 08:04 AM |
Dodge 3500 GVWR
|
Bill Frisbee |
Tow Vehicles & Towing |
2 |
03-29-2006 10:32 AM |
Dodge 3500 2005/06
|
wa4bmg |
Tow Vehicles & Towing |
6 |
06-19-2005 03:14 PM |
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|