|
04-04-2007, 06:12 AM
|
#1
|
Seasoned Camper
Join Date: Jun 2005
Location: elliott
Posts: 65
M.O.C. #4055
|
frame on 3475
what and where do you look to find out about broken frame and also i am haveing trouble with the remote therostatic . any help would be appreciated thamk you darrell
|
|
|
04-04-2007, 12:27 PM
|
#2
|
Montana Master
Join Date: Nov 2005
Location: cedar rapids
Posts: 703
M.O.C. #4962
|
What year is your 3475? I have a 06 and there has been,that I know of, no frame problems. The remote thermostat should have been replaced a while back by the dealer. There has been many posts on both problems. They replaced a board in the air conditioner. Also a new thermostat on the wall. Ours was replaced and works great now. On the frame you might e-mail MIMF2 and ask him. With the smooth?????? roads we have today it's a wonder ANY frame holds up. Good luck
|
|
|
04-04-2007, 01:11 PM
|
#3
|
Montana Master
Join Date: Jun 2003
Location: King George
Posts: 688
M.O.C. #345
|
The frame problems were on the earlier 2000-2002 models. I know of no one that is having problems with the later models. WE have the 2005 3475 and have had no problems with it. Keystone did replace our duotherm thermostat by replacing the board in the ac and a new thermostat on the wall. Our dealer ordered it and replaced everything.
|
|
|
04-04-2007, 04:10 PM
|
#4
|
Montana Fan
Join Date: Sep 2004
Location: Livingston
Posts: 474
M.O.C. #2056
|
Our '04 3575 sure had a frame problem. If you read other forums, you will find that many manufacturers who use Lippert frames like Keystone have had frame problems. The easiest way to check for a frame problem is to check the corners where the frame angles down from the bedroom overhang area while you have the 5W hooked to the tow vehicle with the weight off the legs. You will see movement along the trim where it pulls away from the side. Also watch the hitchpin as you go down the road for excessive movement--more than 1/2" Good luck, there have been lots of discussion regarding this problem. Search for "frame flex".
|
|
|
04-04-2007, 04:11 PM
|
#5
|
Montana Master
Join Date: Nov 2002
Location: Oceanside
Posts: 20,028
M.O.C. #20
|
Del, there was a frame problem with early year models with the 8 inch frame. That's what Ken is referring to.
There was also a problem with some FW's in the overhang area. Is that what you are referring to? The problem only occured in a relatively small number of them. The fix was to add gusseting (spelling?) to beef up the overhang area. Montanas starting with sometime in the 2006 model year run have that additional gusseting from the beginning. There should be no problem with those.
If you think you have the overhang problem, you'll see some separation of the trim along the bottom of the overhang, either on the horizontal piece or the vertical piece that runs down near the front locker door. Our 2003 had a gap where that vertical trim piece turned the corner to head across the front of the rig. It also had some separation at the horizontal trim piece on the side of the overhang. Last, we could see where the dresser dropped below the caulk line maybe a quarter inch, where the dresser meets the closet wall. This is on a 2003 model. Newer models may not have the dresser in that position. In all cases, the gap, or separation, is identifiable only when hitched with the weight on the pin. If you have this, contact Keystone. Phone, don't email.
Awhile back I posted a picture with arrows showing where to look but I cannot find that picture. I have search this laptop high and low.
|
|
|
04-05-2007, 04:24 AM
|
#6
|
Montana Master
Join Date: Jan 2006
Location: San Antonio
Posts: 1,298
M.O.C. #5165
|
Our 2006 3475 is doing just fine. We towed it about 7000 miles the first year. The only issue was the Dometic refrig that was replace free at Camping World. No frame problems or thermostat problems.
__________________
F-250 King Ranch Crew Cab 2012, Single Wheel, 6.7 L Diesel, Transfer Flow Internal 50 Gallon Fuel Tank, Upgraded Ford Software for 50 Gallon tank, 2006 3475Rl with Mor-ryde King Pin, 2nd AC, 2nd Battery, Pressure Pro TPMS, Wet Bolt Shackle Kit
|
|
|
04-05-2007, 05:27 AM
|
#7
|
Seasoned Camper
Join Date: Jun 2006
Location: San Antonio
Posts: 55
M.O.C. #5867
|
We had problems with the remote thermostat and it was replaced with a wall unit when we had some minor things taken care of. No charge to us....works like a dream now.
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
Similar Threads
|
Thread |
Thread Starter |
Forum |
Replies |
Last Post |
Frame flex/broken frame
|
gjetzen |
Montana Problems, Problem Solving & Technical Help |
5 |
05-08-2016 01:42 PM |
New 3475
|
leev |
Member News |
9 |
10-15-2006 07:28 PM |
AC in 3475 RL
|
montanaman |
Montana Problems, Problem Solving & Technical Help |
5 |
04-23-2006 12:33 PM |
Our New 3475
|
Chester |
General Discussions about our Montanas |
15 |
03-09-2005 11:19 AM |
new and looking at the 3475
|
Montana_3166 |
General Discussions about our Montanas |
14 |
02-23-2005 01:18 PM |
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|