Go Back   Montana Owners Club - Keystone Montana 5th Wheel Forum > GENERAL DISCUSSIONS > General Discussions about our Montanas
Click Here to Login

Reply
 
Thread Tools Display Modes
 
Old 10-02-2019, 03:08 PM   #1
RVRoadrambler
New Member
 
Join Date: Jun 2019
Location: Box Elder
Posts: 3
M.O.C. #24372
Solar Question: No more 50A's after 2000W AIMS Inverter

Question regarding solar on our RV.
We had Solar installed on our Montana, which we love having, however, we have had an issue from the beginning that at first we didn't think too much about,but as we have gone along weve grown more and more suspect that something may not be quite right with the way it was installed. The issue is that our Rig is setup for 50A service when plugged into shore power, but since the solar install we experience the inability to use heavy load appliances such as the coffe pot with say the microwave or even just the living room fireplace by itself without tripping the output circuit breaker located on the AIMS 2000W inverter/charger.
The inverter states that it has an internal automatic transfer switch (ATS) which I had thought should sense power present from the pole and pass that 50A current through to the main breaker panel to supply the circuits as normal and then when unplugged would then switch to the battery bank to supply power limitted to the 2000W rating of the inverter to the main panel.
I called AIMS tech support, but they are saying that the inverter will only allow us to have the 2000W, which seems rediculous to us, but I don't know. Does this sound accurate? And if so, is there a way to wire this thing so that we have the ability to use 50A when available and then switch over to the inverter when we are boondocking?

Thanks
RVRoadrambler is offline   Reply With Quote
Old 10-02-2019, 05:04 PM   #2
DQDick
Montana Master
 
DQDick's Avatar
 
Join Date: Jun 2011
Location: Wilsey
Posts: 16,821
M.O.C. #11455
Sounds like you may have the wrong type of inverter, but yes you can add an external transfer switch to bypass the inverter when on shore power. I did that with our old rig after I had an inverter go bad and keep me from using anything that was run thru it. I did it so if the inverter failed I could bypass it. In your case you could use it to bypass the inverter until you wanted to use it. The problem you are having we never had with our 4,000 watt inverter.
__________________
Dick, Joyce, Diego, Picatso and Gustav
2017 3720 RL, MorRyde pin box
2017 3500 Dodge Maxi DRW 4X4, Pullrite Hitch, IS, Disk Brakes, 3rd AC, Winegard Traveler, Bathroom door mod, Dometic 320, couch for desk swap, etc.
DQDick is offline   Reply With Quote
Old 10-02-2019, 05:27 PM   #3
jetskier
Montana Fan
 
jetskier's Avatar
 
Join Date: Aug 2018
Location: Minden - NV
Posts: 251
M.O.C. #22360
Yeah, bypassing the inverter is the only way to solve it. You likely only have a 20A breaker for the whole trailer wired into the inverter/charger rather than the two legs of the 50A. The external 50A ATS will solve that problem.
__________________
2013 F350 Lariat Ultimate CC LB
2019 3790RD
jetskier is offline   Reply With Quote
Old 10-02-2019, 07:16 PM   #4
Drifty1
Montana Master
 
Join Date: Jul 2009
Location: Olympia
Posts: 1,011
M.O.C. #9441
Our Inverter is installed in a similar configuration as yours and we do not have a problem running extra appliances. We do have a MAGNUM 3012 Hybrid which allows me to set the amount of power I want to draw from the shore connection and the rest of needed power comes from your batteries. So it sounds like to me your Inverter is to small to handle the load in your configuration. We have had no problems with our trailer power but we also only figure on 30 power coming in. I am not a expert on trailer power but I know a lot of MOC members are and will be posting shortly.
__________________
2002 3295RK, Magmun Hybrid 3012 inverter with 1305 watt solar at 82 volts. Midnite Classic 150 controller
4ea. 150 AH Lifepo4 batteries , Flex Air pin box, Mor/ryde I/S,disc brakes. RF Mogul dish.
Drifty1 is offline   Reply With Quote
Reply

Tags
2000w, aims, inverter, solar

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by Montana RV, Keystone RV Company or any of its affiliates. This is an independent, unofficial site.


All times are GMT -6. The time now is 02:56 PM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2020, vBulletin Solutions, Inc.
×