|
10-27-2010, 02:26 PM
|
#1
|
Montana Fan
Join Date: Oct 2010
Location: Austin
Posts: 127
M.O.C. #10861
|
hydrolic fluid leak....
Guys,
I need some advice. I have a 2007 Keystone Montana 3400RL. I have had it for about 2 months. I have been out twice in it and all was good. This past weekend when we took it out, I noticed that hydrolic fluid had leaked into the pan beneath the pump.
I stood watch over the pump while my wife pulled the slides in then fully extended them. I never once saw a leak or spurt. However, with the slides pulled in, the hydrolic fluid tank is about a 1/2 inch lower than it was when I bought the rig.
So how do I find the source of the leak? Suggestions.....
Regards,
Chris
|
|
|
10-27-2010, 03:30 PM
|
#2
|
Montana Master
Join Date: Jun 2007
Location: St.Maries
Posts: 1,010
M.O.C. #7329
|
There is a reservoir tank mounted with four bolts to the pump. The magic seal for this contraption is an O ring. I have been trying to get a O ring to seal and hold for more than 6 months for the last four years. I now keep a paper towel on the tray and change it every few days. A roll of paper towels and a quart of WallMart ATF is a lot cheaper than having the seals replaced every few months. I hope you have better luck with yours than I have with mine.
|
|
|
10-27-2010, 03:36 PM
|
#3
|
Montana Master
Join Date: Nov 2002
Location: Midlothian
Posts: 956
M.O.C. #40
|
When I first bought our unit I Filled the reservoir as the directions said. It was a cold day and all went well for a while until the weather warmed, then I noticed the tray was full of hydraulic fluid. I mopped it out of the tray and have never had another problem with leaking. I think when the oil warmed it expanded and overflowed. I now keep it a little lower than what they say to allow for expansion. This may also be your problem. Good luck and just keep a check to make sure it does not get lower.
|
|
|
10-27-2010, 03:40 PM
|
#4
|
Montana Master
Join Date: Feb 2008
Location: Hillsboro
Posts: 593
M.O.C. #8238
|
Chris, as mentioned we too have the '07 3400. As yet (knock on wood) we have not had a hydraulic leak. However, others have mentioned that at times, the plastic housing that holds the fluid can leak where it is attached to the pump. I believe there is a "o-ring" there? Also, it didn't happen to be overfilled and blew it out the top when the slides retracted, did it? Other then that, the leak could be several places. But, since you said you found oil in the pan under the pump, I would suspect the plastic housing seal first. It doesn't always leak, so it may take a few trys to find it if that is where it's coming from. The other possibility would be one of the fittings on the pump distribution header COULD be loose/cracked, and be leaking fluid, but again, not all the time. Kind of like water leaks, sometimes hydraulic ones can be hard too. At least the "evidence" stays behind a lot longer........
Hope this helps, at least a little bit.
__________________
Terry and Patsy
Vietnam Veteran, US Navy
2017 3810
2015 GMC Sierra 4X4 3500 SRW
|
|
|
10-27-2010, 03:49 PM
|
#5
|
Montana Fan
Join Date: Oct 2010
Location: Austin
Posts: 127
M.O.C. #10861
|
Thanks guys for the information. I really appreciate it. I think for now I will mop everything up and mark the fluid level on the tank and keep an eye on it. (Plus put a can of fluid in the camper for emergencies...)
Is there a specific type of hydrolic fluid that I need?
Thanks,
Chris
|
|
|
10-27-2010, 05:10 PM
|
#6
|
Site Team
Join Date: Aug 2007
Location: Omaha
Posts: 6,750
M.O.C. #7560
|
Chris check out the thread on Hydraulic Fluid under the Maintenance section of MOC on MARS. It will tell you exactly what to use and keep in your unit! Read MIMF's comment especially since he is "The Man" when it comes to slides an the hydraulics for them! Good luck and keep us posted on your unit and leak!
|
|
|
10-27-2010, 06:26 PM
|
#7
|
Montana Fan
Join Date: Apr 2008
Location: Pittsburg
Posts: 117
M.O.C. #8384
|
DO any of you think tranny fluid with stop leak may help those with a very small seal leak. I believe it is suppose to swell up the seal. What would it hurt to try it.
|
|
|
10-28-2010, 02:50 AM
|
#8
|
Montana Master
Join Date: Aug 2007
Location: Waterford
Posts: 3,693
M.O.C. #7500
|
Quote:
quote:Originally posted by ljensen
DO any of you think tranny fluid with stop leak may help those with a very small seal leak. I believe it is suppose to swell up the seal. What would it hurt to try it.
|
I'm thinking probably not. I believe it works via the heat generated by the transmission, and these systems don't generate heat - at least nothing near what a transmission does.
|
|
|
10-28-2010, 04:57 PM
|
#9
|
Montana Master
Join Date: Jun 2007
Location: St.Maries
Posts: 1,010
M.O.C. #7329
|
It is just a bogus setup. The reservior should be mounted on the tray and they should use a hose to move the fluid in and out of the tank. That transfer hose wouldn't even have to hold any pressure as that is from the pump to the cylinders.
|
|
|
11-01-2010, 01:20 AM
|
#10
|
Montana Master
Join Date: Mar 2003
Location: Albuquerque
Posts: 703
M.O.C. #235
|
I have the same problem so I call Lippert ? who ever makes it they told me the pump (o-ring) has a 5 YEAR WARRANTY I'm talking mind in next week to have the pump replaced for free, to solve my leaking O-RING problem. You might call them. Hope this helps. Jack
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
Similar Threads
|
Thread |
Thread Starter |
Forum |
Replies |
Last Post |
Fluid Leak
|
CATCRAW |
Montana Problems, Problem Solving & Technical Help |
1 |
07-14-2013 06:38 AM |
Hydrolic slide leak
|
Kimo |
Maintenance |
3 |
05-02-2013 03:37 AM |
hydrolic fluid
|
syplace |
General Discussions about our Montanas |
2 |
03-03-2009 03:18 AM |
Hydrolic Cylinder Leak
|
Ronnelly |
Repairs & Service |
4 |
09-12-2006 05:51 AM |
Slide fluid leak
|
Montana_3288 |
Montana Problems, Problem Solving & Technical Help |
4 |
08-14-2006 04:54 PM |
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|